卡特C系列挖掘机的发动机故障代码表

卡特C系列发动机故障代码表

Flash Code SPN (1)/FMI Code Diagnostic Code 

or 

Event Code Description of Code 

13 174-03 174-03 Fuel Temperature open/short to +batt 

燃油温度传感器或线路故障

174-04 174-04 Fuel Temperature short to ground 

燃油温度传感器或线路故障

16 626-05 2417-05 Ether Injection Control Solenoid open/short to +batt 

乙醚喷射控制电磁阀或线路故障

626-06 2417-06 Ether Injection Control Solenoid short to ground 

乙醚喷射控制电磁阀或线路故障

21 678-03 41-03 8 Volt DC Supply short to +batt 

8V直流电源故障

678-04 41-04 8 Volt DC Supply short to ground 

8V直流电源故障

620-03 262-03 5 Volt Sensor DC Power Supply short to +batt 

5V直流电源故障

1079-03 

620-04 262-04 5 Volt Sensor DC Power Supply short to ground 

5V直流电源故障

1079-04 

24 100-03 100-03 Engine Oil Pressure open/short to +batt 

机油压力传感器或线路故障

100-04 100-04 Engine Oil Pressure short to ground 

机油压力传感器或线路故障

100-10 100-10 Engine Oil Pressure abnormal rate of change 

机油压力更新率不正常

25 102-03 102-03 Boost Pressure Sensor short to +batt 

增压压力传感器或线路故障

102-04 102-04 Boost Pressure Sensor short to ground 

增压压力传感器或线路故障

102-10 102-10 Boost Pressure Sensor abnormal rate of change 

增压压力更新率不正常

102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal 

进气压力传感器电压高于正常值

102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal 

进气压力传感器电压低于正常值

102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change 

进气压力更新率不正常

26 108-03 274-03 Atmospheric Pressure open/short to +batt 

大气压力传感器或线路故障

108-04 274-04 Atmospheric Pressure short to ground 

大气压力传感器或线路故障

27 110-03 110-03 Engine Coolant Temperature open/short to +batt 

冷却液温度传感器或线路故障

110-04 110-04 Engine Coolant Temperature short to ground 

冷却液温度传感器或线路产

28 91-13 91-13 Throttle Position calibration required 

油门需要校准

32 91-08 91-08 Throttle Position signal abnormal 

油门信号不正常

34 190-08 190-08 Engine Speed signal abnormal 

发动机转速信号不正常

723-08 342-08 Secondary Engine Speed signal abnormal 

备用发动机转速信号不正常

35 190-15 E362 (1) Engine Overspeed Warning 

发动机超速报警

190-00 E362 (3) Engine Overspeed Shutdown 

发动机超速停机

37 94-03 94-03 Fuel Pressure open/short to +batt 

燃油压力传感器或线路故障

94-04 94-04 Fuel Pressure short to ground 

燃油压力传感器或线路故障

38 105-03 172-03 Intake Manifold Air Temp open/short to +batt 

进气温度传感器或线路故障

105-04 172-04 Intake Manifold Air Temp short to ground 

进气温度传感器或线路故障

42 637-13 261-13 Engine Timing calibration required 

发动机正时需校准

46 100-17 E360 (1) Low Engine Oil Pressure Warning 

机油压力低报警

100-18 E360 (2) Low Engine Oil Pressure Derate 

机油压力低降载

100-01 E360 (3) Low Engine Oil Pressure Shutdown 

机油压力低停机

51 168-00 168-00 System Voltage high 

系统电压高

168-01 168-01 System Voltage low 

系统电压低

168-02 168-02 System Voltage intermittent/erratic 

系统电压不正常

56 630-02 268-02 Check Programmable Parameters 

发动机参数设置需检查

58 639-09 247-09 J1939 Data Link communications 

J1939数据链接故障

61 110-15 E361 (1) High Engine Coolant Temperature Warning 

冷却液温度高报警

110-16 E361 (2) High Engine Coolant Temperature Derate 

冷却液温度高降载

110-00 E361 (3) High Engine Coolant Temperature Shutdown 

冷却液温度高停机

62 111-17 E2143 (1) Low Engine Coolant Level Warning 

冷却液位低报警

111-18 E2143 (2) Low Engine Coolant Level Derate 

冷却液位低降载

111-01 E2143 (3) Low Engine Coolant Level Shutdown 

冷却液位低停机

63 94-15 E096 (1) High Fuel Pressure Warning 

燃油压力高报警

64 1636-15 E539 (1) High Inlet Air Temperature Warning 

进气温度高报警

1636-00 E539 (3) High Inlet Air Temperature Shutdown 

进气温度高停机

65 174-15 E363 (1) High Fuel Temperature Warning 

燃油温度高报警

174-16 E363 (2) High Fuel Temperature Derate 

燃油温度高降载

174-00 E363 (3) High Fuel Temperature Shutdown 

燃油温度高停机

67 0441-15 E445 (1) High Auxiliary Temperature Warning 

辅助温度高报警

0441-16 E445 (2) High Auxiliary Temperature Derate 

辅助温度高降载

0441-00 E445 (3) High Auxiliary Temperature Shutdown 

辅助温度高停机

0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt 

辅助温度传感器或线路故障

0441-04 1836-04 Auxiliary Temperature Sensor short to ground 

辅助温度传感器或线路故障

68 1387-15 E443 (1) High Auxiliary Pressure Warning 

辅助压力高报警

1387-16 E443 (2) High Auxiliary Pressure Derate 

辅助压力高降载

1387-00 E443 (3) High Auxiliary Pressure Shutdown 

辅助压力高停机

1387-03 1835-03 Auxiliary Pressure Sensor open/short to +batt 

辅助压力传感器或线路故障

1387-04 1835-04 Auxiliary Pressure Sensor short to ground 

辅助压力传感器或线路故障

71 651-05 001-05 Cylinder #1 Injector open circuit 

1缸喷油器故障

651-06 001-06 Cylinder #1 Injector short 

1缸喷油器故障

72 652-05 002-05 Cylinder #2 Injector open circuit 

2缸喷油器故障

652-06 002-06 Cylinder #2 Injector short 

2缸喷油器故障

73 653-05 003-05 Cylinder #3 Injector open circuit 

3缸喷油器故障

653-06 003-06 Cylinder #3 Injector short 

3缸喷油器故障

74 654-05 004-05 Cylinder #4 Injector open circuit 

4缸喷油器故障

654-06 004-06 Cylinder #4 Injector short 

4缸喷油器故障

75 655-05 005-05 Cylinder #5 Injector open circuit 

5缸喷油器故障

655-06 005-06 Cylinder #5 Injector short 

5缸喷油器故障

76 656-05 006-05 Cylinder #6 Injector open circuit 

6缸喷油器故障

656-06 006-06 Cylinder #6 Injector short

6缸喷油器故障